欢迎访问无锡市思必德科技有限公司网站!公司15年的环氧地坪工程技术经验值得您信赖!!
思必德
 
 
十五年专注于环氧地坪设计施工工程
普通型环氧地坪
环氧砂浆地坪
环氧彩砂地坪
环氧自流平地坪
环氧防静电地坪
环氧玻璃钢(FRP)地坪
乙烯基酯重防腐地坪
非金属金属耐磨地坪
混凝土渗透性密封剂
自流平水泥地坪
丙烯酸地坪
EPPU聚合型工业地坪
停车场地坪
环保型无毒防霉墙面
有机硅丙烯酸室外防腐
PVC地坪
 
当前位置 -> 首页新闻资讯如何保证无锡环氧地坪施工质量的五个关键点 发布时间:(2019/9/14)

如何保证无锡环氧地坪施工质量的五个关键点

标签:混凝土密封固化剂 | 混凝土密封固化剂厂家

环氧地坪漆质量问题,80%以上都是施工技术上出现问题,因此,在进行无锡环氧地坪漆施工时一定要严格把好关,每一道涂层都要注重质量,只有把好质量关,才能做出优质的环氧地坪工程。环氧地坪漆施工工艺说难很难、说简单也很简单,只要掌握好五个要点,就能保证环氧地坪漆的施工质量,做出让客户满意的环氧地坪漆工程。下面就给大家介绍环氧地坪漆施工过程中的五个要点:

More than 80% of the quality problems of epoxy floor paint are in construction technology. Therefore, we must strictly control the construction of epoxy floor paint. Every coating should pay attention to quality. Only if the quality of epoxy floor paint is well controlled, can we make high-quality epoxy floor project. The construction technology of epoxy floor paint is difficult, simple and simple. As long as five points are mastered well, the construction quality of epoxy floor paint can be guaranteed and the project of epoxy floor paint satisfying customers can be made. Here are five key points in the construction of epoxy floor paint. 

1、基础地面处理:做好基础地面的处理工作是做出优质环氧地坪漆工程的前提,环氧环氧地坪漆施工要求基础地面强度要求不低于C25,地面平整度一般要求在2m范围内落差不大于2mm,如地下水位较高则混凝土底层应作好防水处理,含水率不高于8%,没有油污等杂物。处理完毕后,检查基底的质量,避免质量效果不佳,而导致环氧地坪漆涂装效果不佳。

1. Foundation ground treatment: good treatment of foundation ground is the precondition of making high-quality epoxy floor paint project. The construction of epoxy floor paint requires that the strength of foundation ground should not be lower than C25, and that the ground roughness should be less than 2m m in the range of 2m. If the groundwater level is high, the concrete bottom should be waterproof. Water content is not higher than 8%, no oil and other impurities. After treatment, the quality of the base is checked to avoid poor quality effect, which leads to poor coating effect of epoxy floor paint.

2、环氧地坪漆材料的质量:必须选择正规地坪漆厂家生产的有质量保障的材料,所有进场材料都要进行检查,杜绝不合格产品的使用。材料使用时必须按照使用说明严格按照配比进行调配,充分搅拌均匀。

2. Quality of Epoxy Floor Paint Material: Material with quality assurance produced by regular flooring paint manufacturers must be selected. All entrance materials should be inspected to prevent the use of substandard products. Material must be used in accordance with the instructions strictly in accordance with the proportion of mixing, fully mixing evenly.

3、施工工具的选择:环氧地坪漆施工时所用的施工工具如:辊筒、刮刀、漆刷、美纹纸等必须选择优质的产品,避免因地坪施工工具不良所导致的质量问题。

3. Selection of construction tools: The construction tools used in the construction of epoxy floor paint, such as roller, scraper, paint brush, paper and so on, must select high-quality products to avoid the quality problems caused by poor floor construction tools.

4、施工人员技术:要选择经验丰富的施工技术人员,施工人员应熟悉掌握本施工工艺的各项技术指标及施工方法,绝对不允许盲目施工、野蛮操作,特别是面漆施工时,一定要有三年以上工作经验的。

4. Construction technicians: To select experienced construction technicians, construction personnel should be familiar with the technical indicators and construction methods of the construction technology, and absolutely not allow blind construction and barbaric operation, especially when finishing paint construction, must have more than three years of work experience.

5、无锡环氧地坪施工环境:无论封闭底漆、中涂漆、还是面漆,由于胺类固化剂反应一般低于5℃基本不反应,所以涂装环境温度在10℃以上时较佳,如低于这个温度,对涂料则需采取一些改进措施。高湿度也对涂层外观有很大影响,特别要避免在低温高湿环境下施工,所以一般相对湿度小于85%时方能施工。

5. Construction environment: Whether closed primer, intermediate paint or topcoat, because the reaction of amine curing agent is generally lower than 5 C, it is better to apply the environment temperature above 10 C. If it is lower than this temperature, some improvement measures should be taken for the coatings. High humidity also has a great impact on the appearance of the coating, especially to avoid construction in low temperature and high humidity environment, so the general relative humidity is less than 85% before construction.

本站网址:http://www.wuxispeed.com


来源:无锡环氧地坪公司  浏览次数:1042
相关阅读:分析客户对无锡环氧地坪施工中应注意的问题 | 无锡环氧地坪冬季施工注意及施工前的考虑因素 | 无锡环氧地坪膜起皱现象产生的原因和防治措
 
 
产品分类    
普通型环氧地坪 环氧玻璃钢(FRP)地坪 丙烯酸地坪
环氧砂浆地坪 乙烯基酯重防腐地坪 EPPU聚合型工业地坪
环氧彩砂地坪 非金属金属耐磨地坪 停车场地坪
环氧自流平地坪 混凝土密封固化剂 环保型无毒防霉墙面
环氧防静电地坪 自流平水泥地坪 有机硅丙烯酸室外防腐地坪


联系我们
电 话:0510-88706248/13915319875
传 真:0510-88706348
邮 箱:Yxdspeed@163.com
网 址:www.wuxispeed.com
地 址:无锡市东亭锡沪东路11号
版权所有:无锡市思必德科技有限公司    网站关键词:无锡环氧地坪  混凝土密封固化剂  苏ICP备20046775号    技术支持:无锡易商科技    网站地图
友情链接:梳理机 台州讨债公司 合肥讨债公司 金华讨债公司 盐城环氧地坪 合肥停息挂账 无锡保洁公司 脚手架厂家 无锡环氧地坪