水性环氧地坪漆的特性和优点及验收标准

时间:2018年10月31日信息来源:无锡环氧地坪公司 点击: 收藏此文 【字体:

水性环氧地坪漆优点1、水性环氧地坪漆能对各种水泥底材有非常好的附着力,对固化的涂膜有非常好的耐腐蚀性和耐化学药品性能,水性环氧地坪漆涂膜收缩小,还有硬度高和好耐磨性的特点。 2、水性环氧地坪漆是以水作为分散的介质的产品,所以它是没有污染,符合环保要求的环氧地坪漆产品,不燃,储存、运输和使用过程中的安全性得以保障; 3、水性环氧环氧地坪漆可以在室温和潮湿的环境中使用,封闭底漆对水泥基材渗透性好、附着力强,能够封闭水泥的毛细孔,不鼓泡、不剥落、不开裂,克服了溶剂型环氧地坪涂料对水敏感的弱点; 4、水性环氧地坪漆的价格非常的合理,施工性能也好,可以直接加水调节施工的粘度,施工的工具可用水直接清洗,使用方便、涂装成本低。

Water-borne epoxy floor paint has the advantages of 1, water-borne epoxy floor paint can have a very good adhesion to a variety of cement substrates, the cured film has a very good corrosion resistance and chemical resistance, water-borne floor paint film shrinkage is small, there are high hardness and good wear resistance characteristics. 2. Waterborne epoxy floor paint is a product with water as dispersing medium, so it is non-polluting, environmentally friendly floor paint products, non-flammable, storage, transportation and use of the process of safety to be guaranteed; 3. Waterborne epoxy floor paint can be used at room temperature and humid environment, sealing primer to cement-based. Good permeability, strong adhesion, can seal the cement pores, not bubbling, not peeling, not cracking, overcome the solvent-based epoxy floor paint water-sensitive weakness; 4, water-based epoxy floor paint price is very reasonable, construction performance is also good, can directly add water to adjust the viscosity of construction, construction tools available Water direct cleaning is easy to use and low in coating cost.

水性环氧地坪漆的装饰效果极好,施工后地面应该达到表面平整,美观靓丽的要求,因此在验收的时候要看清楚涂层表面的大面积接口处是否平整,光泽度也要达到设计要求(高光泽≥90、有光≥70、半光50~70)。地坪表面不能有色差和颗粒,馒刀印等,但是允许有空气中的浮尘掉落在造成的极小缺陷。水性地坪涂料施工公司完工后的地面要在2-3天后达到实干的情况下,对期地坪硬化度进行检测,当硬度达到完成固化的80%左右才算合格,为了使地面有足够的耐磨性,许多客户都会选择调料不易消沉的地坪涂料进行施工。

The decorative effect of waterborne epoxy floor paint is very good. After construction, the surface of the floor should be smooth and beautiful. Therefore, it is necessary to check whether the large area interface of the coating surface is smooth and the gloss should meet the design requirements (high gloss (> 90), gloss (> 70), and half gloss (> 50 ~ 70). The surface of the floor can not be color difference and particles, steamed bread printing, etc., but allow the air to fall on the dust caused by the very small defects. Waterborne floor coating construction company after completion of the ground in 2-3 days to reach the actual situation, the period of floor hardness testing, when the hardness of the completion of the solidification of about 80% is qualified, in order to make the ground has enough wear resistance, many customers will choose seasoning is not easy to depression of the floor coating construction. 水性环氧地坪漆施工后的地面在进行验收时,还要看其丰满度,也就是指看地面的反光率是否能达到95%,如果低于85%一般都是不合格的,环氧地坪涂膜丰满度不良是指环氧地坪漆涂膜虽然涂得够厚,但从外表看仍然很单薄而且显得干瘪的现象,产生这种现象的原因是因为有些不专业的水性地坪涂料施工公司使用高聚合度的地坪漆,在涂料配方过程中没有把握好树脂基料的选择。这个指标在以前是不受重视的,但是随着社会的进步和人们的要求逐渐提高,这一项指标也渐渐变成了当下环氧地坪验收中比较重要的标准

Waterborne epoxy floor paint construction in the acceptance of the ground, but also to see its fullness, that is, to see whether the reflectance of the ground can reach 95%, if less than 85% are generally unqualified, poor fullness of epoxy floor paint is that although the epoxy floor paint coating is thick enough, but still very thin from the outside and The reason for this phenomenon is that some unprofessional waterborne floor coatings construction companies use high degree of polymerization floor coatings, and do not grasp the choice of resin matrix in the paint formulation process. This index was not paid much attention in the past, but with the progress of the society and the gradual improvement of people's requirements, this index has gradually become an important standard in the acceptance of epoxy floor.

(作者:环氧地坪施工队 编辑:admin)

网友评论

 以下是对 [水性环氧地坪漆的特性和优点及验收标准] 的评论,总共:0条评论

最新文章

推荐文章

热门文章