揭示延长环氧地坪寿命四大注意事项

时间:2018年10月21日信息来源:无锡环氧地坪公司 点击: 收藏此文 【字体:

近年来环氧地坪市场逐渐取代了传统的地板铺设,环氧地坪比起普通地坪铺设费用更低,且无接缝,具有较强的防腐性和耐磨性,下面我们随环氧地坪厂家小编一起来了解一下环氧地坪注意事项有哪些吧。环氧地坪注意事项之环氧地坪表面的处理

In recent years, the epoxy floor market has gradually replaced the traditional floor laying, epoxy floor than the ordinary floor laying cost is lower, and seamless, with strong corrosion resistance and wear resistance, we follow the epoxy floor manufacturer knitted together to understand what the epoxy floor matters needing attention. Treatment of epoxy floor surface for epoxy floor notices

环氧地坪注意事项第一点就是新竣工的水泥地面必须经过一定的养护后方可施工,约28天,铺设前需清除表面的水泥浮浆、旧漆以及粘附的垃圾杂物,彻底清除表面的油污,可以用克油王清洗剂处理,还要清除积水,并使潮处彻底干燥,使表面的清洁需用无尘清扫机及大型吸尘器来完成,平整的表面允许空隙为2~2.5mm,含水量在6%以下,PH值6~8。环氧地坪表面的打毛,需用无尘打磨机来完成,并用吸尘器彻底清洁,对环氧地坪表面的洞孔和明显凹陷处应用环氧砂浆或者环氧腻子来填补批刮,实干后,打磨吸尘。

The first thing to note about the epoxy floor is that the newly completed cement floor must be maintained before it can be constructed. About 28 days before it is laid, it is necessary to remove the cement slurry, old paint and adherent garbage debris on the surface, thoroughly remove the oil stains on the surface, and can be treated with the king of kerosene detergent. It is also necessary to remove the accumulated water and make the tide clear. Bottom drying, so that the surface of the clean need to use dust-free sweeper and large vacuum cleaner to complete, flat surface allowable gap for 2-2.5mm, moisture content below 6%, PH value 6-8. The surface of epoxy floors should be ground with a dust-free grinder and cleaned thoroughly with a vacuum cleaner. Epoxy mortar or putty should be used to fill the holes and obvious depressions on the surface of the epoxy floors. After drying, the floors should be ground and cleaned.

环氧地坪注意事项之施工注意事项

Matters needing attention in construction of epoxy floor

环氧地坪注意事项中施工现场的环境温度应高于5℃,相对湿度小于85%时方能施工,施工者应做好施工部位、时间、温度、相对湿度、地坪表面处理、材料实际等记录,以备查考,涂料施工后,应立即清洗有关设备和工具。

In the precautions of epoxy floor construction site environmental temperature should be higher than 5 C, relative humidity is less than 85% before construction, construction site, time, temperature, relative humidity, surface treatment of the floor, material and other records for reference, after the paint construction, should immediately clean the relevant equipment and tools.

环氧地坪注意事项之安全技术要求

Safety technical requirements for epoxy floor precautions

环氧地坪注意事项在安全方面要求施工场地四周应拉好警戒带和挂好警告牌,施工场地四周10米内严禁明火作业,严禁吸烟,使用高压无气喷涂泵应结妥地线,涂料和稀释剂应放在通风良好的库房内,工作时注意做好个人防护,电动工具的使用须有专人负责,做完离场前需切断电源。

Notice in the safety of the epoxy floor requires that the construction site should be surrounded by a good warning belt and hang a good warning sign, the construction site around 10 meters is strictly prohibited open fire operation, smoking, the use of high-pressure airless spraying pump should be properly grounded, paint and diluent should be placed in a well-ventilated warehouse, work to pay attention to personal protection. The use of electric tools must be responsible for someone who needs to cut off the power before leaving.

环氧地坪注意事项之使用和保养

Use and maintenance of epoxy floor notices

环氧地坪注意事项中保养和使用也是重点,当该涂料施工完毕后,在保养期内切勿使用,并须加强通风设备及防火措施,地坪使用,生产人员不准穿有铁钉的皮鞋在上面行走,一切工作器具都须有固定专用车架安放,严禁带有锐角的金属零件等物件碰撞地面,造成地面涂料损坏。车间内安装设备等重大物件须用起重机械时,在接触地面的支撑点应有厚橡皮等软件材料垫妥,严禁用铁管等金属在地面上接拖设备。车间内进行电焊等高温作业时,在电焊火花飞溅到的地方应用石棉布等耐火材料铺垫好,以防烧坏涂料。一旦地坪有损坏,及时使用涂料修补,以免油污通过损坏处渗透到水泥里,造成大面积涂料脱落。车间内大面积清洗地面时,不要用强化学溶剂(甲苯、香蕉水等)一般使用洗涤剂、肥皂液、清水等,用清洗机进行,在没有清洗机的情况下,可用锯木粉撒上后再清扫干净。冬季施工,环境温度低于5℃,可采用冬用型无溶剂环氧工业地坪涂料。

Maintenance and use of epoxy floors are also important points for attention. When the paint is finished, it should not be used during the maintenance period. Ventilation equipment and fire prevention measures should be strengthened. Floors should be used. Producers should not wear nailed leather shoes to walk on the floors. All working appliances should be installed with a fixed special frame. Strictly prohibited to carry with them. Sharp angle metal parts and other objects collide with the ground, resulting in damage to the ground coating. When installing equipment and other important objects in the workshop, the supporting points on the ground should be padded with thick rubber and other software materials. It is forbidden to use metal pipes and other towing equipment on the ground. When welding and other high-temperature operations are carried out in the workshop, asbestos cloth and other refractories should be used to pave the place where sparks are spattered to prevent the coating from burning out. Once the floor has been damaged, timely use of paint repair, so as not to oil dirt through the damage penetrated into the cement, resulting in a large area of paint off. When cleaning the floor in a large area in the workshop, do not use intensified chemical solvents (toluene, banana water, etc.) general use of detergent, soap, water, etc., with a cleaning machine, in the absence of a cleaning machine, you can use sawdust sprinkled and then clean. In winter construction, the ambient temperature is below 5 C, and winter solventless epoxy industrial floor coatings can be used.

(作者:环氧地坪施工队 编辑:admin)
文章热词:环氧地坪

上一篇:没有了

下一篇:固化地坪和环氧地坪的区别分别是什么?

网友评论

 以下是对 [揭示延长环氧地坪寿命四大注意事项] 的评论,总共:0条评论

最新文章

推荐文章

热门文章