无锡环氧自流平地坪施工最佳环境温度是在10-35℃，温度过低或过高都会对环氧地坪漆施工产生不良影响，无法保证施工后的效果，下面环氧地坪漆厂家就给大家分析温度过低或者过高对环氧地坪漆施工产生的影响。温度高于30度，会导致涂料的稠度增加、干结报废，严重的话还会出现爆聚现象。温度过高对环氧地坪漆施工的影响，导致工人还无法把桶内环氧地坪漆材料施工完，环氧地坪漆就已经没有用了。一般我们都采用少量多次的方法配漆，或者选用沸点高、挥发慢的稀释剂调整温度对环氧地坪漆施工的影响。

The optimum environmental temperature for epoxy floor paint construction is 10-35 C, too low or too high temperature will have a negative impact on the construction of epoxy floor paint, can not guarantee the effect after construction. The following epoxy floor paint manufacturers will give you an analysis of the impact of too low or too high temperature on the construction of epoxy floor paint. If the temperature is higher than 30 degrees, the consistency of the coating will increase, the dry end will be scrapped, and if serious, the explosion will occur. The influence of high temperature on the construction of epoxy floor paint leads to the fact that workers can not finish the construction of floor paint materials in barrels, and floor paint is no longer useful. Generally, we use a small number of times to prepare the paint, or choose a diluent with high boiling point and slow volatilization to adjust the influence of temperature on the construction of epoxy floor paint. 

一、温度过低对环氧地坪漆施工的影响

I. Effect of Low Temperature on Construction of Epoxy Floor Paint

1、减慢涂料反应。

1. Slow down the reaction of paint.

双组分的地坪漆材料(我司的为双组分)施工，需要现场将甲、乙组分按一定比率混合，搅拌均匀，让双组分充分反应，这样才能保证地坪的效果。但如果温度低于5℃，反应将会降低或减缓，这会严重影响地坪涂料的固化性能。而固化性能的降低，将导致涂膜表面干得很慢，会增加涂膜被灰尘，杂物，或者昆虫(苍蝇、蚊子)污染的可能。

In the construction of two-component floor paint materials (our company's two-component), it is necessary to mix components A and B at a certain ratio on site, mix evenly, and make the two components react fully, so as to ensure the effect of the floor. However, if the temperature is lower than 5 C, the reaction will be reduced or slowed down, which will seriously affect the curing performance of floor coatings. Decreased curing performance will result in a slow drying of the film surface, which will increase the possibility that the film will be contaminated by dust, debris, or insects (flies, mosquitoes).

2、黏度成倍增长。

2. Viscosity doubles.

无溶剂的环氧自流平地坪涂料无需刮涂，靠流平性保证地坪的平整度。但低温下，地坪涂料的黏度会成倍增加，流平性能将降低。而不靠流平性的涂料，刮涂时会因为流动、流平性能变差，而出现镘刀痕的缺陷。

Solvent-free epoxy self-leveling floor coating does not need to scratch, depending on leveling to ensure the evenness of the floor. However, at low temperature, the viscosity of the floor coating will be doubled and the leveling performance will be reduced. However, without leveling coating, the defect of trowel marks will appear when scraping because of the poor flow and leveling performance.

3、降低涂膜质量。

3. Reduce the quality of the film.

由于固化反应减慢，或者完成不能固化，涂膜的强度、硬度、耐磨性都将会降低，而且会更容易出现环氧树脂地坪脱离等问题，严重的影响环氧地坪漆的使用寿命。

The strength, hardness and wear resistance of the coatings will be reduced due to the slow curing reaction or the failure of curing, and the problems of epoxy resin floor detachment will occur more easily, which will seriously affect the service life of the epoxy floor paint.